67 FR 42 pg. 9803 - Michelin North America, Inc., Grant of Application for Decision of Inconsequential Noncompliance
Type: NOTICEVolume: 67Number: 42Page: 9803
Docket number: [Docket No. NHTSA 2001-10854; Notice 2]
FR document: [FR Doc. 02-5092 Filed 3-4-02; 8:45 am]
Agency: Transportation Department
Sub Agency: National Highway Traffic Safety Administration
Official PDF Version: PDF Version
DEPARTMENT OF TRANSPORTATION
National Highway Traffic Safety Administration
[Docket No. NHTSA 2001-10854; Notice 2]
Michelin North America, Inc., Grant of Application for Decision of Inconsequential Noncompliance
Michelin North America, Inc., (Michelin) has determined that approximately 1,400 11R24.5 Michelin XDY-EX LRH tires do not meet the labeling requirements mandated by Federal Motor Vehicle Safety Standard (FMVSS) No. 119, "New Pneumatic Tires for Vehicles Other than Passenger Cars," and has filed an appropriate report pursuant to 49 CFR Part 573, "Defect and Noncompliance Reports." Michelin has also applied to be exempted from the notification and remedy requirements of 49 U.S.C. Chapter 301-"Motor Vehicle Safety" on the basis that the noncompliance is inconsequential to motor vehicle safety.
Notice of receipt of the application was published, with a 30-day comment period, on October 29, 2001, in the Federal Register (FR66 54572). NHTSA received no comments.
FMVSS No. 199, S6.5, mandates that the tire identification and the DOT symbol labeling shall comply with 49 CFR part 574.
Michelin's noncompliance relates to the mislabeling of approximately 1,400 tires. The tires are 11R24.5 Michelin XDY-EX LRH truck tires. Michelin states that, "During the period of the 29th week of 2001 through the 36th week of 2001, the Spartanburg, South Carolina plant of Michelin North America produced a number of tires with a portion of the DOT tire identification number marking (as required on one side of the tire by 49 CFR 571.119 S6.5b) which did not meet the labeling specifications as described by 49 CFR 574.5."
Instead of a required marking that reads: "DOT B6 4F BVR X NN01", the tires were marked: "DOT B6 4F NN01 X BVR" where NN is the week of fabrication and 01 is the year. According to Michelin, all performance requirements of FMVSS No. 119 are met or exceeded. Up to 1,200 noncompliant tires have been delivered to end-users. The remaining noncompliant tires have been isolated in Michelin's warehouses and will be either brought into full compliance with the marking requirements of FMVSS No. 119 or scrapped.
Michelin supports its application for inconsequential noncompliance by stating that they do not believe the marking error will impact motor vehicle safety because the tires meet all Federal motor vehicle safety performance standards and the non-compliance is one of labeling.
Michelin has reviewed and strengthened its procedures for detecting this type of error. Instead of checking the first piece of a particular production run at the press, future samples will be taken to a separate inspection station where exact labeling specifications are displayed for comparison. Based on this improvement, the likelihood of future errors of this type is reduced.
The agency believes that in the case of a tire labeling noncompliance, the measure of its inconsequentiality to motor vehicle safety is whether the mislabeling would affect the manufacturer's ability to identify them, should the tires be recalled for performance related noncompliance. In this case, the nature of the labeling error does not prevent the correct identification of the affected tires. 49 CFR 574.5 requires the date code portion of the tire identification number to be placed in the last or right-most position. Michelin's switching of the date code with the third position reserved for optional code information should not cause confusion since that optional information consists of letters, not numbers. Consequently, persons reading the tire identification label would easily be able to identify the four digit date code.
In consideration of the foregoing, NHTSA has decided that the applicant has met its burden of persuasion that the noncompliance it describes is inconsequential to motor vehicle safety. Accordingly, Michelin's application is hereby granted, and the application is exempted from the obligation of providing notification of, and a remedy for, the noncompliance.
(49 U.S.C. 30118, 30120; delegations of authority at 49 CFR 1.50 and 501.8).
Dated: February 22, 2002.
Stephen R. Kratzke,
Associate Administrator, for Safety Performance Standards.
[FR Doc. 02-5092 Filed 3-4-02; 8:45 am]
BILLING CODE 4910-59-P